Int J App Pharm, Vol 14, Issue 1, 2022, 112-115Original Article

FORMULATION OF EFFERVESCENT GRANULES FROM RED GINGER (ZINGIBERIS OFFICINALE ROSCOE VAR. RUBRUM) EXTRACT AND ITS ANTIOXIDANT ACTIVITY

DIAH LIA AULIFA1, DIKI PRAYUGO WIBOWO2, NENI SAFITRI2, ARIF BUDIMAN3

1Department of Pharmaceutical Analysis and Medicinal Chemistry, Faculty of Pharmacy, Universitas Padjadjaran, 2Department of Pharmaceutical Biology, Indonesian School of Pharmacy (Sekolah Tinggi Farmasi Indonesia), JI Soekarno Hatta no. 354, Bandung, Indonesia, 3Department of Pharmaceutics and Pharmaceutical Technology, Faculty of Pharmacy, Universitas Padjadjaran
*Email: diahliaaulifa@gmail.com

Received: 08 Oct 2021, Revised and Accepted: 11 Nov 2021

ABSTRACT

Objective: Ginger is one of the Indonesian plants that has been used as traditional medicine. The flavonoids and phenols compounds contained high antioxidant activity. This study aimed to formulate effervescent granules (EG) from red ginger (RG) extract and evaluate its antioxidant activity.

Methods: The formulation of EG from RG extract was prepared by the wet granulation method using different concentrations of polyvinylpyrrolidone (PVP). Furthermore, the flowability of granules was evaluated, including flow rate, angle of repose, bulk density, tapped density, Carr's index, Hausner ratio, and effervescent time. The physical stability of granules such as organoleptic evaluation, effervescent time, and pH measurement was also evaluated after 28 d of storage, and the antioxidant activity of EG from RG extract was determined using 1,1-diphenyl-2-picrylhydrazyl (DPPH).

Results: The result showed that the EG of RG extract was successfully prepared by wet granulation with a concentration of 15%. In addition, the flowability study showed that all formulas of EG from RG extract have good flow properties, and the granules showed excellent flow properties based on Carr′s index results. The effervescent time of granules remained within the acceptable range according to USP, and the physical stability did not change even after 28 d of storage. The IC50 of EG from RG extract was 283.28±3.6 ppm and has moderate in free radicals scavenging activity.

Conclusion: EG from RG extract can be used as food supplements to protect the human body from free radicals and inhibit oxidases.

Keywords: Red ginger, Effervescent granules, Antioxidant, Flowability

© 2022 The Authors. Published by Innovare Academic Sciences Pvt Ltd. This is an open access article under the CC BY license (https://creativecommons.org/licenses/by/4.0/)
DOI: https://dx.doi.org/10.22159/ijap.2022v14i1.43377. Journal homepage: https://innovareacademics.in/journals/index.php/ijap

INTRODUCTION

Oxidation of biological molecules causes a variety of health problems, including carcinogenesis, Parkinson's disease, atherogenesis, and aging [1]. Previous studies proved that these damaging pathological events are caused by free radicals [2], commonly associated with cell degeneration, especially in the brain. In addition, oxidative stress results from increased reactive oxygen species (ROS) or a decreased antioxidant capacity from a natural cell in organisms [3].

The antioxidants can inhibit ROS to cause DNA damage, coronary heart disease, and health problems related to advancing age [4]. Moreover, scavenging agents can also be used as inhibitors of free radicals [5]. Many antioxidants were obtained from natural sources such as plants and are used in the food industry due to their health benefits [6]. Therefore, consuming foods rich in antioxidants phytochemicals can decrease degenerative diseases caused by oxidative stress to improve antioxidant capacity in the body [3]. One of the potential sources from natural plants that act as antioxidants is red ginger (Zingiberis officinale Roscoe var. rubrum).

Ginger is one of the herbs that have been used as a spice, dietary supplement, and traditional medicine in various cultures globally [5, 7]. Several antioxidants compounds such as ascorbic acid, beta-carotene, polyphenols, and terpenoids are contained in ginger [7]. Several studies reported the antioxidant activity of ginger. In an in vitro and animal experiment conducted by Matsuda et al., ginger exhibited antioxidant activity and it has protective properties against free radical damage [8, 9]. The methanolic extract of ginger favorably prevented ROS damage assessed by ABTS assay (91.04±0.96%), nitric oxide assay (86.72±1.51%), and DPPH assay (86.26±0.97%) [10]. Red and white ginger extract can protect the brain by dietary intake through antioxidant activity and prevent oxidative stress, Fe2+chelating, and OH• scavenging ability [3]. Therefore, it can be a major source of natural or phytochemical antioxidants due to its wide range of antioxidants [11].

Recently, many products have been developed from the gingers, such as skin-lightening cosmetics, tablets, etc. The development of effervescent powder and its antioxidant activity has not been studied. Therefore, this study aimed to formulate the effervescent granules (EG) from red ginger (RG) extract and evaluate its antioxidant activity. EG was chosen as a product because it is soluble, dissolves quickly, and does not have a bad bitter taste. It is one of the most popular oral products due to its stable dosage forms and convenience [12].

MATERIALS AND METHODS

Plant and microbiological material

The RG was collected from Kutawaringin, Bandung, West Java, Indonesia, and authenticated (No. 26/HB/04/2021) by Plant Taxonomy Laboratory, Faculty of Mathematics and Natural Sciences (FMIPA), Universitas Padjadjaran. Bacteria Staphylococcus aureus ATCC6538 and Escherichia coli ATCC8939 were obtained from the microbiology laboratory school of pharmacy, Bandung Institute of Technology.

Chemicals

Vitamin C and DPPH were purchased from Tokyo Chemical Industry, while other chemicals were purchased from pharmaceutical grade.

Methods

RG extract preparation

The RG powder (300 g) was placed into a round-bottom flask containing 3 L of 96% ethanol as solvent and extracted using the reflux extraction method. Furthermore, the solvent was removed by using the rotary evaporator to obtain the crude extract (37.41 g).

Phytochemical screening of the extract

The phytochemical screening was conducted to detect the secondary metabolites contained in ginger such as alkaloids, flavonoids, monoterpenes and sesquiterpenes, steroids/triterpenoids, polyphenols, quinones, saponins, and tannins [13].

Formulation of EG from RG extract

The wet granulation method was used to prepare the EG from RG extract [12]; the formula and quantity of each component are shown in table 1. In the acid components, the RG crude extract, citric acid, and tartaric acid were mixed with other ingredients thoroughly to maintain good distribution of the sample. A suitable amount of binding agent was added and the mixture powder was sieved using sieve no. 12 to obtain granules. The obtained granules were dried at 45 ᵒC overnight using the oven to obtain<0,5% of the water content. Similar preparation was also conducted for the base component, which contains sodium bicarbonate and others. Furthermore, both components were mixed, sieved through sieve no. 14, and dried to form granules.

Table 1: The formula of EG from RG extract

Components F1 (%) F2 (%) F3 (%)
RG extract 15 15 15
Mannitol 28.3 27.8 27.3
Citric acid 9.4 9.4 9.4
Tartaric acid 18.8 18.8 18.8
Sodium bicarbonate 23.5 23.5 23.5
Polyvinylpyrrolidone (PVP) 2 2.5 3
Sucrose 3 3 3

Flowability study

The flow rate and the angle of repose determination

The funnel method was conducted to measure the flow rate and angle of repose. When granules samples are poured onto a horizontal plane, a conical pile will be formed. Furthermore, the angle of repose is the internal angle between the surface of the pile and the horizontal surface. The flow rate and the angle of repose of the sample were calculated as follows:

Flow rate = w/t

Where w is the weight (gram) and t is time (second).

While for the angle of repose:

θ=tan−1(h x r)

Where h is the height of the granules forming the cone and r is the radius of the base [12, 14].

Bulk density (BD) and tapped density (TD)

Two types of BD and TD were determined using the methods outlined in USP. Meanwhile, 25 g of granules were put into a 100 ml measuring cylinder, and the initial volume was measured. The measuring cylinder was tapped and the volume was measured in increments of 10, 50, and 100 taps. From the equation below, BD and TD were calculated [12, 14].

Compressibility index (CI) and hausner ratio (HR)

CI and HR of granules were measured to provide the flow properties and compressibility of EG from RG [15]. The values were compared with references, as shown in table 2 [12, 14].

Effervescence time

The effervescent time of granules was measured by adding 1 g of EG from RG to a glass containing 100 ml of water, and the time for obtaining a clear solution was recorded [16].

Physical stability

The physical stability of EG from RG extract was evaluated after 28 d of storage, including organoleptic evaluation, effervescent time, and pH measurement.

Antioxidant activity

The antioxidant activity of EG from RG extract was measured by the DPPH assay [17], and the sample solution was prepared by various concentrations, mixed with DPPH solution in a ratio of 2:3. Furthermore, the absorbance was measured at 517 nm and calculated to obtain the inhibition percentage value using the following equation:

% Inhibition = [ 1–(Asample/ADPPH)] x100

Where % Inhibition is the percentage capacity of free radical inhibition, and ADPPH is the absorbance of DPPH solution at 515 nm. The linear regression curve between % inhibition and sample concentration (IC50) was calculated8 and vitamin C was used as a reference compound [18].

Table 2: Flow properties of the angle of repose [12, 14]

Angle of repose Flow properties
<20 Excellent
20-30 Good
30-40 Slightly poor
>40 Very poor

Table 3: Table of compressibility index [12, 14]

Flow characters Carr's index

Excellent

Good

Fair

Slightly poor

poor

Very poor

Extremely poor

1-10

11-15

16-20

21-25

26-31

32-37

>38

Table 4: Table of hausner’s ratio of granules [12, 14]

Hausner’s ratio Flowing properties

<1.25

1.25-1.6

>1.6

Good

Moderate

more cohesive powders

RESULTS AND DISCUSSION

The result of phytochemical screening showed that RG extract contained flavonoids, monoterpenes and sesquiterpenes, steroids/triterpenoids, polyphenols, quinones, saponins, and tannins. Meanwhile, phenolic compounds protect the human body from free radicals due to their antioxidants capacity. The antiradical activity of phenols and flavonoids is based on the structural relationship between different parts of their chemical structure [19, 20]. Natural polyphenols can remove free radicals, activate antioxidant enzymes, reduce α-tocopherol radicals, and inhibit oxidases [21, 22].

The dose of EG from RG extract used in this study was 15%, and the concentration of the antibacterial activity against Staphylococcus aureus and Escherichia coli was reported [23]. In addition, 15% red ginger extract was used, and it had an antibacterial activity of 12.9 mm and 13.5 mm against Staphylococcus aureus and Escherichia coli, respectively.

In the formula of EG from RG extract, mannitol was added as filler, binder, and lubricant to improve flowability and reduce friction [24]. PVP is a nontoxic and hydrophilic excipient used in various pharmaceutical formulations, especially in the solid dosage form. In this formula, PVP was added as a binder to form granules materials and improve the properties of RG extract [25]. In this formula, sucrose was used as a sweetening agent and a diluent [26]. The combination of sodium bicarbonate-citric and tartaric acid was commonly used as effervescent material in the formulations of effervescent [27].

Table 5 showed the results of the flowability study of EG from RG extract, and the values of the angle of repose from EG were found in the range 25.72-26.32 with a flow rate of 4.87-5.27. The value of bulk and tapped density were in the range of 39.17-45.37, and 36.97-42.67, respectively. The result of the carr′s index of EG from RG extract was in the range of 5.78-5.95, and the Hausner′s ratio values were found in the range of 1.04-1.06. These results demonstrated that all the formulas have good flow properties, and the granules showed excellent flow properties based on Carr′s index results. The good or excellent flow properties of granules were attributed to the successful method of preparation using wet granulation [12].

Table 5: Flow properties of ginger effervescent granules (the data were calculated as mean±SD; n=3)

Formula Flow rate (g/s) Angle of repose (°) Bulk density Tapped density Carr′s index Hausner′s ratio
F 1 4.87±0.13 26.32±0.21 45.37±0.12 42.67±0.58 5.95±1.17 1.06±0.02
F 2 5.06±0.09 25.99±0.19 43.03±0.06 40.01±0.01 6.89±0.35 1.04±0.01
F 3 5.27±0.15 25.72±0.33 39.17±0.15 36.97±0.06 5.78±0.57 1.05±0.06

The results of EG from RG extract are shown in table 6, and the values of effervescence time were found in the range of 144–190 s, and these results were in acceptable range according to USP [28].

Table 6: The results of effervescent time measurement (the data were calculated as mean±SD; n=3)

Formula Effervescent time (sec)
F1 144±3.2
F2 173±2.5
F3 190±1.3

The physical stability was monitored from organoleptic evaluation, effervescent time, and pH measurement, and the sample appearances (fig. 1), color, and odor of granules did not change after 28 d of storage. Moreover, the effervescence time was still in the acceptable range according to USP, and the pH of EG from RG extract after being dissolved in the water can be seen in fig. 2. The results showed that the pH did not significantly change after 28 d of storage and remained within the acceptable range for the effervescent solution which is between 6-7 [28].

Fig. 1: Sample appearances of EG from RG extract

The result of antioxidant activity of EG from RG extract is shown in table 4, and the formula chosen as the sample was F3 because its effervescence time was faster than others. Therefore, F1 is assumed to be the best formula compared to others.

Fig. 2: pH of EG from RG extract after dissolved in the water (the data were calculated as mean±SD; n=3)

Table 7: The antioxidant activity result of each sample (the data were calculated as mean±SD; n=3)

Sample IC50 of antioxidant activity (µg/ml)
Ginger extract 144.42±4.3
EG from RG extract (F1) 283.28±3.6
Vitamin C 16.36±1.4

The ginger and EG from RG extract showed antioxidant activity at ICC values of 144.42 g/ml and 283.28 g/ml, respectively, while vitamin C was 16.36 g/ml. Furthermore, the IC50 of ginger effervescent granules was lower compared to extracts as well as vitamin C as standard. However, these granules can remove free radicals since their IC50 showed moderate antioxidant activity. This indicated that flavonoids and phenols remain in ginger effervescent granules. Therefore, EG from RG extract can be used as a food supplement to protect the human body from free radicals and inhibit oxidases.

CONCLUSION

This study explains the formulation of EG from RG extract and its antioxidant activity. The flowability study and effervescent measurement showed that EG was successfully prepared by wet granulation. Furthermore, the DPPH assay demonstrated its moderate antioxidant activity. Therefore, this study provided fundamental insight that EG from RG extract can be used as food supplements to protect the human body from free radicals and inhibit oxidases.

ACKNOWLEDGMENT

This research was supported by Hazanah Foundation, Indonesian School of Pharmacy, through the Fundamental Research Grant number 009/SPK/YHZ/II/2019.

FUNDING

Nil

AUTHORS CONTRIBUTIONS

All the author have contributed equally.

CONFLICT OF INTERESTS

Declared none

REFERENCES

  1. Finkel T, Holbrook NJ. Oxidants, oxidative stress and the biology of ageing. Nature. 2000;408(6809):239-47. doi: 10.1038/35041687, PMID 11089981.

  2. Halliwell B, Gutteridge JM. Free radicals in biology and medicine. Oxford: Oxford University Press; 2015.

  3. Oboh G, Akinyemi AJ, Ademiluyi AO. Antioxidant and inhibitory effect of red ginger (Zingiber officinale var. Rubra) and white ginger (Zingiber officinale Roscoe) on Fe(2+) induced lipid peroxidation in rat brain in vitro. Exp Toxicol Pathol. 2012;64(1-2):31-6. doi: 10.1016/j.etp.2010.06.002, PMID 20598871.

  4. Patel RP, Moellering D, Murphy Ullrich J, Jo H, Beckman JS, Darley Usmar VM. Cell signaling by reactive nitrogen and oxygen species in atherosclerosis. Free Radic Biol Med. 2000;28(12):1780-94. doi: 10.1016/s0891-5849(00)00235-5, PMID 10946220.

  5. Yeh HY, Chuang CH, Chen HC, Wan CJ, Chen TL, Lin LY. Bioactive components analysis of two various gingers (Zingiber officinale Roscoe) and antioxidant effect of ginger extracts. LWT Food Sci Technol. 2014;55(1):329-34. doi: 10.1016/j.lwt.2013.08.003.

  6. Ibanez E, Kubatova A, Senorans FJ, Cavero S, Reglero G, Hawthorne SB. Subcritical water extraction of antioxidant compounds from rosemary plants. J Agric Food Chem. 2003;51(2):375-82. doi: 10.1021/jf025878j, PMID 12517098.

  7. Ghasemzadeh A, Jaafar HZ, Rahmat A. Antioxidant activities, total phenolics and flavonoids content in two varieties of Malaysia young ginger (Zingiber officinale Roscoe). Molecules. 2010;15(6):4324-33. doi: 10.3390/molecules15064324, PMID 20657444.

  8. Masuda Y, Kikuzaki H, Hisamoto M, Nakatani N. Antioxidant properties of gingerol-related compounds from ginger. BioFactors. 2004;21(1-4):293-6. doi: 10.1002/biof.552210157, PMID 15630214.

  9. Ahmed RS, Seth V, Pasha ST, Banerjee BD. Influence of dietary ginger (Zingiber officinales Rosc) on oxidative stress induced by malathion in rats [Zingiber officinales Rosc]. Food Chem Toxicol. 2000;38(5):443-50. doi: 10.1016/s0278-6915(00)00019-3, PMID 10762730.

  10. Murugesan S, Venkateswaran MR, Jayabal S, Periyasamy S. Evaluation of the antioxidant and anti-arthritic potential of Zingiber officinale Rosc. by in vitro and in silico analysis. S Afr J Bot. 2020;130:45-53. doi: 10.1016/j.sajb.2019.12.019.

  11. Kikuzaki H, Nakatani N. Antioxidant effects of some ginger constituents. J Food Sci. 1993;58(6):1407-10. doi: 10.1111/j.1365-2621.1993.tb06194.x.

  12. Ji AM, Al-Hussainy Za AM. Formulation and evaluation of effervescent granules of ibuprofen. Int J Appl Pharm. 2019;11:66-9.

  13. Budiman A, Aulifa DL. A study comparing the antibacterial activity of Ageratum conyzoides L. extract and Piper betle L. extract in gel dosage forms against Staphylococcus aureus. Pharmacogn J. 2020;12(3):473-7. doi: 10.5530/pj.2020.12.73.

  14. Shah RB, Tawakkul MA, Khan MA. Comparative evaluation of flow for pharmaceutical powders and granules. AAPS PharmSciTech. 2008;9(1):250-8. doi: 10.1208/s12249-008-9046-8, PMID 18446489.

  15. Senthil P, Suresh Kumar CH, Raju N, Mohideen S. Formulation and evaluation of gastric oral floating tablet of glipzide. Int J Biol Pharm Res. 2010;1:108-13.

  16. Sandhya S, Gowthami G, Vinod KR, VidyaSravanthi E, Saikumar P, Rao Knv. Formulation and evaluation of herbal effervescent granules incorporated with Limnophila indica extract for bacillary dysentery. Ann Bio Res. 2012;3:63-72.

  17. Aulifa DL, Caroline M, Tristiyanti D, Budiman A. Formulation of the serum gel containing green coffee bean (Coffea robusta L.) extract as an antioxidant and tyrosinase enzyme inhibitor. Rasayan Journal of Chemistry 2020;13:2346-51. doi: 10.31788/RJC.2020.1345866

  18. Budiman A, Khaira N, Aulifa DL. Peel-off gel formulation from black mulberries (Morus nigra L.) leaves extract as a tyrosinase inhibitor. Int J Drug Deliv Technol. 2019;9:525-9.

  19. Rice Evans CA, Miller NJ, Paganga G. Structure-antioxidant activity relationships of flavonoids and phenolic acids. Free Radic Biol Med. 1996;20(7):933-56. doi: 10.1016/0891-5849(95)02227-9, PMID 8743980.

  20. Iwansyah AC, Damanik RM, Kustiyah LI, Hanafi M. Relationship between antioxidant properties and nutritional composition of some galactopoietic herbs used in indonesia: a comparative study. Int J Pharm Pharm Sci. 2016;8(12):236-43. doi: 10.22159/ijpps.2016v8i12.14964.

  21. Amic D, Davidovic Amic D, Beslo D, Trinajstic N. Structure-radical scavenging activity relationships of flavonoids. Croat Chem Acta. 2003;76:55-61.

  22. Alía M, Horcajo C, Bravo L, Goya L. Effect of grape antioxidant dietary fiber on the total antioxidant capacity and the activity of liver antioxidant enzymes in rats. Nutr Res. 2003;23(9):1251-67. doi: 10.1016/S0271-5317(03)00131-3.

  23. Wibowo DP, Mariani R, Hasanah SU, Aulifa DL. The chemical composition, antibacterial activity and mechanism of action essential oil of red ginger (Zingiber officinale var. Rubra species from Bogor West Java Indonesia. Int J Pharmacol Res. 2019;11:1210-5.

  24. Soliman KA, Ibrahim HK, Ghorab MM. Formulation of risperidone as self-nano emulsifying drug delivery system in the form of effervescent tablets. J Dispers Sci Technol. 2012;33(8):1127-33. doi: 10.1080/01932691.2011.599235.

  25. Zheng X, Wu F, Hong Y, Shen L, Lin X, Feng Y. Improvements in sticking, hygroscopicity, and compactibility of effervescent systems by fluid-bed coating. RSC Adv. 2019;9(54):31594-608. doi: 10.1039/C9RA05884B.

  26. Nguyen VT. Effect of binder and sweeteners on the production of effervescent artichoke (Cynara scolymus L.) tea tablets. J Food Process Preserv. 2013;37(6):1078-83. doi: 10.1111/j.1745-4549.2012.00808.x.

  27. Shirsand SB, Suresh S, Jodhana LS, Swamy PV. Formulation design and optimization of fast disintegrating lorazepam tablets by an effervescent method. Indian J Pharm Sci. 2010;72(4):431-6. doi: 10.4103/0250-474X.73911, PMID 21218052.

  28. The United States Pharmacopeia (USP). NF28 Convention Inc. USA: United States Pharmacopeia; 2010.